一、用車前進行檢查

1、 Conduct safety checks before using the vehicle

1、仔細檢查自上料攪拌車各部件是否正常

1. Carefully check whether all components of the self feeding mixer truck are normal

做好措施，防止裝料的自動上料混凝土攪拌車壞在路上?；炷列枰煌５臄噭右苑乐鼓?，如果出現故障導致攪拌罐停轉，很容易出現悶罐。一般停罐不能超過2個小時，C40往上級別的混凝土基本就不能停。

Take safety measures to prevent the automatic loading concrete mixer truck from damaging on the road. Concrete needs to be stirred continuously to prevent solidification. If a malfunction causes the mixing tank to stop rotating, it is easy to cause tank blockage. Generally, the tank cannot be stopped for more than 2 hours, and concrete with a C40 level or higher cannot be stopped.

啟動自上料攪拌車前，必須先檢查機油、潤滑油和冷卻水等物料是否充足，及時進行添加。車子啟動后，低速旋轉罐體，繞車一周檢測胎壓，防止有漏氣車胎，用工具拿掉卡在輪胎中石子等雜物。

Before starting the self feeding mixer truck, it is necessary to check whether the materials such as engine oil, lubricating oil, and cooling water are sufficient and add them in a timely manner. After the car starts, rotate the tank at low speed and test the tire pressure around the car to prevent any air leaks. Use tools to remove debris such as stones stuck in the tires.

其次檢驗燈光是否正常，務必保證照著輪胎邊緣，防止被工地堆放的鋼筋雜物割傷。清理干凈后視鏡和窗戶玻璃，司機保持清晰開闊視野，以應對工地的復雜工況場景。

Secondly, check whether the lighting is normal, and make sure to illuminate the edge of the tire to prevent it from being cut by the steel bars and debris piled up on the construction site. Clean the rearview mirror and window glass, and the driver maintains a clear and open view to cope with the complex working conditions of the construction site.

2、準備足夠的水和減水劑

2. Prepare sufficient water and water reducing agent

水可以應對混凝土物料干燥無法卸料的情況，減水劑也是同理，防止悶罐。

Water can cope with situations where concrete materials are dry and cannot be unloaded, and the same applies to water reducing agents to prevent tank tightness.

3、啟動攪拌車時確保攪拌罐處于靜止狀態

3. Ensure that the mixing tank is stationary when starting the mixer truck

發動機啟動時罐子如果處于高速旋轉狀態，瞬間的力會非常大，容易使減速機磨損，降低使用壽命。

When the engine starts, if the jar is in a high-speed rotating state, the instantaneous force will be very large, which is easy to cause wear on the gearbox and reduce its service life.

二、行車要慢

2、 Drive slowly

1、拐彎的時候一定要慢

1. Be slow when turning

自上料攪拌車高，高速行駛容易發生事故。入彎之前提前減速減擋，盡量別在拐彎的時候踩剎車。隨時注意觀察攪拌罐是否在轉，把轉速盡量調慢，轉速過高，車輛產生擺動，出現側翻。

The center of gravity of the self feeding mixer truck is high, and high-speed driving is prone to accidents. Slow down and downshift before entering the corner, and try not to apply the brake when turning. Always pay attention to whether the mixing tank is rotating, and try to slow down the speed as much as possible. If the speed is too high, the vehicle will sway and roll over.

自動上料混凝土攪拌車在傾斜角大的路段需要停下罐。滿載料時走到傾斜角度大的路段，停止罐體的轉動可以使車輛行駛的更加平穩。

The automatic loading concrete mixer truck needs to stop the tank on sections with large inclination angles. When fully loaded, walking to a section with a large inclination angle and stopping the rotation of the tank can make the vehicle travel more smoothly.

2、爛路請低速擋通過

2. Bad road, please pass in low gear

遇到路面不平，坑坑洼洼地方用合適的低速擋通過，保證車隨時有爆發力。注意避讓雜物。

When encountering uneven road surfaces or potholes, use a suitable low-speed gear to pass through, ensuring that the car has explosive power at any time. Be careful to avoid debris.

3、上坡提前減檔

3. Advance downshifting on uphill

起步要平穩，不能亂減檔，提前減檔，保持車輛充足的動力。

Start smoothly, do not downshift randomly, downshift early, and maintain sufficient power of the vehicle.

4、下坡禁止空擋滑行

4. No neutral sliding when going downhill

長時間行駛或者下坡前都要習慣的測試一下剎車。禁止攪拌車空擋滑行下坡，采用低檔位發動機減速，下坡路段出現彎路，要在拐彎時提前減速再減擋再減速，帶擋剎車效果好。

Be accustomed to testing the brakes before driving for a long time or downhill. It is prohibited for the mixer truck to slide downhill in neutral. Low gear engines should be used to slow down. If there are bends in the downhill section, it is necessary to slow down in advance and then downshift before decelerating. The braking effect with gear is good.

5、一定要注意限高

5. Be sure to pay attention to the height limit

運輸前提前規劃好路線，注意限高，工地路況復雜，要小心樹木，要防止刮到線纜。

Plan the route in advance before transportation, pay attention to height restrictions, and be careful of the complex road conditions on the construction site. Be careful of trees and prevent scratching the cables.

使用自動上料混凝土攪拌車的幾個要點相關內容就講解到這里了，希望能夠給您好的幫助，更多相關事項就來我們網站http://www.kunapops.com咨詢！

That's all for explaining the key points of using an automatic concrete mixer truck. We hope it can be helpful to you. For more related matters, please come to our website http://www.kunapops.com consulting service